污视频app网址丝瓜视频

Welcome to Sichuan Chengtianyi Electromechanical Equipment Co., Ltd.!

发电机出租
Chengtianyi Electromechanical Equipment Service Hotline 13808070896
contact us
Service Hotline
028-85784642
Mr. Sun: 13808070896
Ms. Chen: 15828360146
QQ: 532234632
Email: 532234632@qq.com
Address: Huangshui Town, Shuangliu County, Chengdu
How to maintain the diesel generator in winter
Browse: Release Date: 2019-12-17
How to maintain the diesel generator in winter
There are power outages and outages in many public places across the country. "After years of technical transformation, Shangchai has built a series of safe and reliable generating units, and it is necessary to do daily maintenance of the units. The diesel generator rental will tell you how to maintain the diesel generating units in winter.
I. Open flame start
In places where the temperature is low, the machine can be started with an open flame, but the air filter cannot be removed. Use cotton yarn dipped in diesel to ignite, and then put the igniter into the intake pipe to start the combustion. In this way, during the startup process, the external dusty air will be directly sucked into the cylinder without being filtered, causing abnormal wear of the pistons, cylinders and other components, and will also cause the diesel engine to run erratically and damage the diesel generator rental .
How to maintain the diesel generator in winter
Whether to discharge the cooling water prematurely
The generator runs at idle speed before stopping. When the temperature of the cooling water drops below 60 ° C, the water will not be hot, and then the flame will be turned off. If the cooling water drains too early and is attacked by cold air at high temperatures, the body will suddenly contract and crack. When draining water, the remaining water in the fuselage should be drained to prevent frost heaving and cause the fuselage to expand and crack. Shun Jinxing recommends that users use antifreeze in any season, and higher level generator sets use antifreeze. Because antifreeze can not only cool down, but also protect the rental of diesel generators.
Selection of lubricant
In winter, oil with a lower freezing point should be used. When starting, external oil bath heating can be used to increase the oil temperature. It is not recommended to use open flames, in order to prevent the oil in the oil pan from deteriorating, even burning, reducing or completely losing the lubricating performance, thereby increasing the wear of the machine. Diesel generator rental.
Fourth, the starting method
In winter, if conditions permit, each generator is equipped with a water jacket heater so that the machine can maintain a certain "temperature" and can be easily operated at any time. In order to quickly start diesel generator sets, some operators often use abnormal waterless starting methods (starting first, then adding cooling water). This practice will cause serious damage to the machine and should not be used. The correct preheating method is: first cover the heat preservation cover on the water tank, open the water drain valve, and continuously inject clean soft water at 60-70 ° C into the water tank, touch the water flowing from the water drain valve with your hands to feel hot, and then close the water drain valve Then start the drain valve.
How to maintain the diesel generator in winter
V. Precautions for low temperature load
After the diesel generator set caught fire, some operators could not wait to start the load operation immediately. Due to the low body temperature and the high viscosity of the oil, it is difficult for the oil to be injected into the moving friction surface, causing serious engine wear. In addition, plunger springs, valve springs, and injector springs are prone to break due to "cold brittleness". Therefore, after the diesel generator starts to catch fire in winter, it should be idled for a few minutes at low and medium speeds. After the cooling water temperature reaches 60 ° C, the diesel generator will be put into operation with a load and leased.
Six, engine fuel
Low temperature in winter tends to increase the viscosity of diesel oil and worsen its fluidity, making it difficult for diesel to inject, resulting in poor atomization, worse combustion, and reducing the power and economics of diesel engines. Therefore, light diesel oil with low freezing point and good ignition performance should be used in winter. Generally, the freezing point of diesel engines should be lower than the local low temperature of 7 ~ 10 ° C.
Generator rental -Sichuan Chengtianyi Electromechanical Equipment Co., Ltd. is a company specializing in leasing and selling diesel generators and leasing and selling electromechanical equipment. The company has a wide range of generators and comprehensive services. .